Metathesis of 1-hexene over rhenium oxide supported on ordered mesoporous aluminas:: comparison with Re2O7/γ-Al2O3

被引:49
作者
Aguado, J [1 ]
Escola, JM [1 ]
Castro, MC [1 ]
Paredes, B [1 ]
机构
[1] Rey Juan Carlos Univ, Dept Chem Environm & Mat Technol, Escuela Super Ciencias Expt & Tecnol, Mostoles 28933, Spain
关键词
metathesis; 1-hexene; gamma-Al2O3; MSU; rhenium oxide; sol-gel mesoporous alumina;
D O I
10.1016/j.apcata.2005.01.017
中图分类号
O64 [物理化学(理论化学)、化学物理学];
学科分类号
070304 ; 081704 ;
摘要
Self-metathesis of 1-hexene was carried out at 40 degrees C over Re2O7 supported on two micelle templated aluminas (sol-gel mesoporous alumina (SGAL) and MSU), prepared with cationic and neutral surfactant, respectively, and a reference Re2O7/gamma-Al2O3 catalyst with the same rhenium oxide content (similar to 9 wt%). Both mesostructured catalysts (Re2O7/MSU and Re2O7/SGAL) showed similar activity and far higher than that of the reference Re2O7/gamma-Al2O3 catalyst, with a selectivity towards the self-metathesis products above 99%. Among the tested solvents, dodecane yielded the highest conversion likely because of its low polarity and better product removal. Similar TOF values were obtained for Re2O7/SGAL catalysts with mesopore diameter within the 5.0-12.0 nm range. In relation with the rhenium content, all optimum in TOF values was detected for rhenium oxide loadings within 6-10 wt%. The increase in activation temperature within 550-700 degrees C led towards a greater rise in activity over Re2O7/SGAL catalysts than over Re2O7/gamma-Al2O3. DRIFT chemisorbed pyridine spectra disclosed only Lewis acid sites over the activated catalysts and in higher amounts over both mesostructured catalysts. P-31 MAS NMR spectra of chemisorbed triethylphosphine oxide (TEPO) indicated the presence of three kind of acid sites (delta similar to 58, 68 and 80 ppm), with a higher content of strong Lewis acid sites (80 ppm) over both mesostructured catalysts. The remarkable performance of both ordered mesoporous catalysts was ascribed to the presence of these strong Lewis acid sites, likely stemming from the interaction of linked rhenium species with the weak Lewis acid sites of the support. (c) 2005 Elsevier B.V. All rights reserved.
引用
收藏
页码:47 / 57
页数:11
相关论文
共 38 条
  • [1] TEMPERATURE-PROGRAMMED REDUCTION OF AL2O3-, SIO2-, AND CARBON-SUPPORTED RE2O7 CATALYSTS
    ARNOLDY, P
    VANOERS, EM
    BRUINSMA, OSL
    DEBEER, VHJ
    MOULIJN, JA
    [J]. JOURNAL OF CATALYSIS, 1985, 93 (02) : 231 - 245
  • [2] Mesoporous alumina molecular sieves
    Bagshaw, SA
    Pinnavaia, TJ
    [J]. ANGEWANDTE CHEMIE-INTERNATIONAL EDITION IN ENGLISH, 1996, 35 (10): : 1102 - 1105
  • [3] Rhenium oxide supported on mesoporous organized alumina as a catalyst for metathesis of 1-alkenes
    Balcar, H
    Hamtil, R
    Zilková, N
    Cejka, J
    [J]. CATALYSIS LETTERS, 2004, 97 (1-2) : 25 - 29
  • [4] Bielawski CW, 2000, ANGEW CHEM INT EDIT, V39, P2903, DOI 10.1002/1521-3773(20000818)39:16<2903::AID-ANIE2903>3.0.CO
  • [5] 2-Q
  • [6] Cabrera S, 1999, ADV MATER, V11, P379, DOI 10.1002/(SICI)1521-4095(199903)11:5<379::AID-ADMA379>3.0.CO
  • [7] 2-6
  • [8] CHEMICAL COUNTING AND CHARACTERIZATION OF THE ACTIVE-SITES IN THE RHENIUM OXIDE ALUMINA METATHESIS CATALYST
    CHAUVIN, Y
    COMMEREUC, D
    [J]. JOURNAL OF THE CHEMICAL SOCIETY-CHEMICAL COMMUNICATIONS, 1992, (06) : 462 - 464
  • [9] Activation of the Re2O7/Al2O3 metathesis catalyst by aryloxyaluminium complexes
    Commereuc, D
    Olivier-Bourbigou, H
    Kruger-Tissot, V
    Saussine, L
    [J]. JOURNAL OF MOLECULAR CATALYSIS A-CHEMICAL, 2002, 186 (1-2) : 215 - 222
  • [10] A METHOD FOR THE CALCULATION OF COMBINED PHASE AND CHEMICAL-EQUILIBRIA - THERMODYNAMICS OF THE METATHESIS OF 1-OCTENE IN THE LIQUID-PHASE
    DEKKER, FHM
    SPRONK, R
    MOL, JC
    [J]. FLUID PHASE EQUILIBRIA, 1993, 84 : 321 - 338