Influence of aging on structure and thermal conductivity of Y-PSZ and Y-FSZ EB-PVD coatings

被引:63
作者
Azzopardi, A
Mévrel, R
Saint-Ramond, B
Olson, E
Stiller, K
机构
[1] Off Natl Etud & Rech Aerosp, DMMP, F-92322 Chatillon, France
[2] Chalmers Univ Technol, S-41296 Gothenburg, Sweden
[3] Snecma Moteurs, YKOS, F-77556 Moissy Cramayel, France
关键词
zirconium oxide; electron beam evaporation; thermal barrier coatings; thermal conductivity;
D O I
10.1016/j.surfcoat.2003.08.073
中图分类号
TB3 [工程材料学];
学科分类号
0805 ; 080502 ;
摘要
The surface temperature of the ceramic layer of thermal barrier coatings is likely to increase in future, due to the introduction of systems with lower thermal conductivity. This study aims at describing and understanding how the crystallographic structure and the microstructure of EB-PVD coatings can change after aging at high temperature, and how the thermal conductivity of the ceramic layer is affected. The structures of two EB-PVD yttria-zirconia coatings have been studied (one partially stabilized, the other fully stabilized) by XRD, SEM and TEM after heat treatments at temperatures ranging between 1100 and 1500 degreesC up to 100 h. Their thermal diffusivity has been determined up to 1000 degreesC by a laser flash method. The results show that: (1) no or little monoclinic phase is detected in the Y-PSZ coatings after aging; (2) phase transformations in Y-PSZ coatings lead to the formation of a band structure; and (3) shrinkage due to the constrained sintering of the coating results in transverse cracks. The thermal conductivity results are discussed in relation with these structural evolutions. (C) 2003 Elsevier B.V. All rights reserved.
引用
收藏
页码:131 / 139
页数:9
相关论文
共 24 条
[1]  
AZZOPARDI A, 2002, MAT 2002 TOURS FRANC
[2]  
BISSON JF, 2000, J AM CERAM SOC, V71, P255
[3]  
DEMANGE D, 1999, REV METALLURGIE SCI, P649
[4]  
DINWIDDIE RB, 1996, INT GAS TURB AER C E
[5]  
HASSELMAN DPH, 1987, AM CERAM SOC BULL, V66, P799
[6]  
HEUER AH, 1988, ADV CERAM, V24, P3
[7]  
KLEMENS PG, 1997, NASA TBC WORKSH 97, P15
[8]  
LECLERCQ B, 2002, THESIS LIMOGES U FRA
[9]   MICROSTRUCTURAL INVESTIGATIONS OF EBPVD THERMAL BARRIER COATINGS [J].
LELAIT, L ;
ALPERINE, S ;
DIOT, C .
JOURNAL DE PHYSIQUE IV, 1993, 3 (C9) :645-654
[10]   Distributed porosity as a control parameter for oxide thermal barriers made by physical vapor deposition [J].
Lu, TJ ;
Levi, CG ;
Wadley, HNG ;
Evans, AG .
JOURNAL OF THE AMERICAN CERAMIC SOCIETY, 2001, 84 (12) :2937-2946