Thermal and structural behavior of milk fat - 3. Influence of cooling rate and droplet size on cream crystallization

Crystallization of triacylglycerols (TG) within milk fat globules of creams is studied with an instrument coupling time-resolved synchrotron X-ray diffraction (XRDT) at both small and wide angles and high-sensitivity differential scanning calorimetry (DSC) at cooling rates of -3 and -1degreesC/min from 60 to -10degreesC and compared to that of the anhydrous milk fat (AMF). Simultaneous thermal analysis permits correlation of the formation of the different crystalline species monitored by XRDT to the DSC events. Under the above cooling conditions, milk fat TG sequentially crystallize, within the globules, from about 19degreesC, in three different lamellar structures with double-chain length (2L) stackings of 47 and 42 Angstrom and a triple-chain length (3L) stacking of 71 Angstrom, all of alpha type, which are correlated to two or three overlapped exothermic peaks recorded by DSC. Compared to what is observed for AMF, TG crystallization in emulsion (i) favors sub-alpha formation at low temperature and (ii) induces layer stacking defects in 3L crystals. Subsequent heating at 2degreesC/min shows numerous structural rearrangements before final melting, confirming that (i) cooling at -1degreesC/min leads to the formation of unstable crystalline varieties in the dispersed state and (ii) a monotropic transition alpha-->beta' takes place. Similar behavior is observed for cooling at -3degreesC/min and subsequent heating. An overall comparison of the thermal and structural properties of the crystalline species formed as a function of the cooling rate, between > 1000 and 0.15degreesC/min, and stabilization time at 4degreesC is given. Depending on the cooling rate, at least five crystalline subcell species are observed at wide angles, alpha and sub-alpha, two beta' and one beta. At small angles, at least six lamellar stackings are identified, three 3L and three 2L. However, a single subcell packing (e.g., alpha) might correspond to several longitudinal chain stackings, demonstrating the usefulness of the small-angle XRD technique. Reconstituted emulsions homogenized under different pressures are used to determine the influence of droplet size on crystallization. The decrease of droplet size induces (i) a higher supercooling/supersaturation and (ii) a higher disorder and/or a smaller size of TG crystals within the emulsion droplets. At the supramolecular scale, polarized light microscopy shows that various cooling rates applied in situ using a temperature-controlled stage directly influence crystal sizes and their type of organization within milk fat globules. The faster the cooling rate, the smaller the size of the crystals within the globules. (C) 2002 Elsevier Science (USA).