Hybrid chemical vapor Deposition/Sol-Gel route in the preparation of nanophasic LaCoO3 films

被引:30
作者
Armelao, L
Barreca, D
Bottaro, G
Gasparotto, A
Maragno, C
Tondello, E
机构
[1] Univ Padua, ISTM, CNR, Dept Chem, I-35131 Padua, Italy
[2] Univ Padua, INSTM, Dept Chem, I-35131 Padua, Italy
关键词
D O I
10.1021/cm0489643
中图分类号
O64 [物理化学(理论化学)、化学物理学];
学科分类号
070304 ; 081704 ;
摘要
Lanthanum cobaltite (LaCoO3) thin films were synthesized by an innovative route based on the combination of chemical vapor deposition (CVD) and sol-gel (SG) methods. In particular, the approach is based on the sequential deposition of binary oxide systems (Co-O on La-O) and on the ex situ thermal treatment of the final product (T = 400-900 degreesC, t = 1-8 h), aimed at favoring solid-state reactions for the formation of a ternary La-Co-O nanosystem. To highlight the peculiar effects of these procedures on the characteristics of the final product, both SG and CVD routes were used for the preparation of single-phase La-O and Co-O species. The process resulted in the formation of LaCoO3 nanostructured films with an average crystallite size lower than 20 nm. The required processing conditions were strongly dependent on the specific synthetic pathway: (i) SG of Co-O on CVD La-O; (ii) CVD of Co-O on SG La-O. In this framework, particular attention was focused on the analogies and differences between the two sequences and on a study of the most relevant compositional, structural, and morphological system features.
引用
收藏
页码:427 / 433
页数:7
相关论文
共 49 条
  • [1] Innovative approaches to oxide nanosystems:: CeO2-ZrO2 nanocomposites by a combined PE-CVD/sol-gel route
    Armelao, L
    Barreca, D
    Bottaro, G
    Gasparotto, A
    Tondello, E
    Ferroni, M
    Polizzi, S
    [J]. CHEMICAL VAPOR DEPOSITION, 2004, 10 (05) : 257 - 264
  • [2] LaCoO3 Nanopowders by XPS
    Armelao, Lidia
    Bettinelli, Marco
    Bottaro, Gregorio
    Barreca, Davide
    [J]. Surface Science Spectra, 2001, 8 (01): : 24 - 31
  • [3] Sol-Gel and CVD Co3O4 Thin Films Characterized by XPS
    Armelao, Lidia
    Barreca, Davide
    Gross, Silvia
    Tondello, Eugenio
    [J]. Surface Science Spectra, 2001, 8 (01): : 14 - 23
  • [4] Synthesis and characterization of nanophasic LaCoO3 powders
    Armelao, L
    Bandoli, G
    Barreca, D
    Bettinelli, M
    Bottaro, G
    Caneschi, A
    [J]. SURFACE AND INTERFACE ANALYSIS, 2002, 34 (01) : 112 - 115
  • [5] Cobalt oxide-based films: sol-gel synthesis and characterization
    Armelao, L
    Barreca, D
    Gross, S
    Martucci, A
    Tieto, M
    Tondello, E
    [J]. JOURNAL OF NON-CRYSTALLINE SOLIDS, 2001, 293 : 477 - 482
  • [6] ARMELAO L, 2003, ELECTROCHEM SOC P, V8, P1119
  • [7] ARMELAO L, 1998, SCI TECHNOL CULTURAL, V7, P41
  • [8] Dense ceramic membranes for partial oxidation of methane to syngas
    Balachandran, U
    Dusek, JT
    Mieville, RL
    Poeppel, RB
    Kleefisch, MS
    Pei, S
    Kobylinski, TP
    Udovich, CA
    Bose, AC
    [J]. APPLIED CATALYSIS A-GENERAL, 1995, 133 (01) : 19 - 29
  • [9] Barreca D, 2001, CHEM MATER, V13, P588, DOI 10.1021/cm00104lx
  • [10] Structural characterization of sol-gel lanthanum cobaltite thin films
    Bontempi, E
    Armelao, L
    Barreca, D
    Bertolo, L
    Bottaro, G
    Pierangelo, E
    Depero, LE
    [J]. CRYSTAL ENGINEERING, 2002, 5 (3-4) : 291 - 298