The use of a thermophilic anaerobic system for pretreatment of textile dye wastewater

被引:22
作者
Willetts, JRM [1 ]
Ashbolt, NJ [1 ]
Moosbrugger, RE [1 ]
Aslam, MR [1 ]
机构
[1] Univ New S Wales, Sch Civil & Environm Engn, Ctr Water & Waste Technol, Sydney, NSW 2052, Australia
关键词
anaerobic wastewater treatment; decolouration; textile dyes; thermophilic; up-flow anaerobic sludge blanket;
D O I
10.2166/wst.2000.0529
中图分类号
X [环境科学、安全科学];
学科分类号
08 ; 0830 ;
摘要
A thermophilic up-flow anaerobic sludge blanket (UASB) reactor was investigated for the decolouration of a synthetic textile wastewater. Textile wastewater is produced at high temperature and dyes are amenable to decolourisation under anaerobic conditions, however this is the first report of the use of such a thermophilic system to aid in the treatment of this wastewater. The decolouration efficiency and robustness of the thermophilic system were compared with a corresponding mesophilic anaerobic system to study the reduction of a selection of reactive dyes, the toxic effect of increasing influent dye concentration (up to 0.64 g.L-1), and the response during acclimation to high salinity conditions (up to 20 g.L-1 as sodium chloride) in three separate stages of experimentation. It was shown that compared with the mesophilic system, the thermophilic UASB treatment gave considerably higher dye decolouration with all the dyes tested, and under all operating conditions investigated. No loss in decolourisation potential was observed during an increase in influent dye concentration. However, toxicity effects were evident, noted by a decrease in COD removal and methane gas production. Acclimation to high salt concentrations also showed an adverse effect upon COD removal and gas production, however dye removal again remained virtually 100 % efficient.
引用
收藏
页码:309 / 316
页数:8
相关论文
共 23 条
[1]   STATUS ON SCIENCE AND APPLICATION OF THERMOPHILIC ANAEROBIC-DIGESTION [J].
AHRING, BK .
WATER SCIENCE AND TECHNOLOGY, 1994, 30 (12) :241-249
[2]   Microbial decolorization of textile-dye-containing effluents: A review [J].
Banat, IM ;
Nigam, P ;
Singh, D ;
Marchant, R .
BIORESOURCE TECHNOLOGY, 1996, 58 (03) :217-227
[3]   THE DEGRADATION OF DYESTUFFS .1. PRIMARY BIODEGRADATION UNDER ANAEROBIC CONDITIONS [J].
BROWN, D ;
LABOUREUR, P .
CHEMOSPHERE, 1983, 12 (03) :397-404
[4]   MEMBRANE TECHNOLOGY FOR THE TREATMENT OF DYEHOUSE EFFLUENTS [J].
BUCKLEY, CA .
WATER SCIENCE AND TECHNOLOGY, 1992, 25 (10) :203-209
[5]  
BUMPUS JA, 1995, BIOTRANSFORMATIONS M, P157
[6]  
COOPER P, 1993, J SOC DYERS COLOUR, V109, P97
[7]   CHARACTERIZATION OF TEXTILE WASTEWATERS - A REVIEW [J].
CORREIA, VM ;
STEPHENSON, T ;
JUDD, SJ .
ENVIRONMENTAL TECHNOLOGY, 1994, 15 (10) :917-929
[8]  
Dubrow S.F., 1996, ENV CHEM DYES PIGMEN, P75
[9]   ENHANCED BIODEGRADATION OF AROMATIC POLLUTANTS IN COCULTURES OF ANAEROBIC AND AEROBIC BACTERIAL CONSORTIA [J].
FIELD, JA ;
STAMS, AJM ;
KATO, M ;
SCHRAA, G .
ANTONIE VAN LEEUWENHOEK INTERNATIONAL JOURNAL OF GENERAL AND MOLECULAR MICROBIOLOGY, 1995, 67 (01) :47-77
[10]   OZONATION - AN IMPORTANT TECHNIQUE TO COMPLY WITH NEW GERMAN LAWS FOR TEXTILE WASTE-WATER TREATMENT [J].
GAHR, F ;
HERMANUTZ, F ;
OPPERMANN, W .
WATER SCIENCE AND TECHNOLOGY, 1994, 30 (03) :255-263