Evaluation of automated RT-PCR to accelerate the laboratory diagnosis of foot-and-mouth disease virus

Automated fluorogenic (5' nuclease probe-based) reverse transcription polymerase chain reaction (RT-PCR) procedures were evaluated for the diagnosis of foot-and-mouth disease (FMD) using suspensions of vesicular epithelium, heparinised or clotted blood, milk and oesophageal-pharyngeal fluid ('probang') samples from the United Kingdom (UK) 2001 epidemic and on sera from animals experimentally infected with the outbreak scrotype O FMD virus strain. A MagNA Pure LC was initially programmed to automate the nucleic acid extraction and RT procedures with the PCR amplification carried out manually by fluorogenic assay in a GeneAmp(R) 5700 Sequence Detection System. This allowed 32 samples to be tested by one person in a typical working day or 64 samples by two people within 10-12 h. The PCR amplification was later automated and a protocol developed for one person to complete a single test incorporating 96 RT-PCR results within 2 working days or for two people to do the same thing in around 12 h. The RT-PCR results were directly compared with those obtained by the routine diagnostic tests of ELISA and virus isolation in cell culture. The results on blood, probang and milk samples were in broad agreement between the three procedures but specific RTPCR protocols for such material have to be fully optimised as perhaps have the positive-negative acceptance criteria. However, the automated RT-PCR achieved definitive diagnostic results (positive or negative) on supernatant fluids from first passage inoculated cell cultures and its sensitivity was greater than ELISA on suspensions of vesicular epithelium (ES) and at least equivalent to that of virus isolation in cell culture. The combined tests of ELISA, virus isolation in cell culture and RT-PCR might, therefore, only be required for confirmation of a first outbreak of FMD in a previously FMD-free country. Should a prolonged outbreak subsequently occur, then either ELISA plus RT-PCR or else RT-PCR alone could be used as the laboratory diagnostic tool(s). Either approach would eliminate the requirement for sample passage in cell culture and considerably advance the issue of laboratory diagnostic test results. (C) 2002 Elsevier Science B.V. All rights reserved.