Platinum catalysts on alumina and silica prepared by gas- and liquid-phase deposition in cinnamaldehyde hydrogenation

被引:50
作者
Lashdaf, M
Lahtinen, J
Lindblad, M
Venäläinen, T
Krause, AOI
机构
[1] Helsinki Univ Technol, Dept Chem Technol, FIN-02015 Helsinki, Finland
[2] Helsinki Univ Technol, Phys Lab, FIN-02015 Helsinki, Finland
[3] Fortum Oil, Oil Res & Technol, FIN-06101 Porvoo, Finland
[4] Univ Joensuu, Dept Chem, FIN-80101 Joensuu, Finland
关键词
platinum catalyst; (trimethyl)methylcyclopentadienylplatinum; cinnamaldehyde; gas-phase deposition; impregnation; ALE reactor; cinnamyl alcohol;
D O I
10.1016/j.apcata.2004.07.050
中图分类号
O64 [物理化学(理论化学)、化学物理学];
学科分类号
070304 ; 081704 ;
摘要
Platinum catalysts supported on alumina and silica were prepared by gas-phase deposition and impregnation using (trimethyl)methylcyclopentadienylplatinum(IV) as precursor. The deposition from the gas-phase was carried out at 100degreesC with nitrogen as carrier gas, and in impregnation, the deposition was carried out with toluene as solvent at room temperature in inert atmosphere. In both cases, a ligand exchange reaction of the platinum precursor occurred with the support surface with simultaneous reduction of platinum(IV) to platinum(II) and platinum(0). Post-treatment of the catalyst materials was studied by direct reduction under hydrogen (only impregnated catalysts) and by calcination in air prior to reduction. The catalysts were characterised by CO-chemisorption, temperature-programmed reduction (TPR) and Xray photoelectron spectroscopy (XPS). The catalytic activity and selectivity were assessed by hydrogenation of cinnamaldehyde. The results showed that the support, the method of preparation and post-treatment influence the dispersion and catalytic properties. A calcination step before the reduction increased the dispersion values on both alumina and silica. The catalysts on alumina support had high dispersion, > 90%, whereas the catalysts supported on silica had a dispersion of 36% when produced in the gas-phase and 24% when produced by impregnation. The catalysts on silica support were more active in cinnamaldehyde hydrogenation than those on alumina support. The impregnated platinum catalyst supported on silica showed selectivity to cinnamyl alcohol up to 90% at conversion of 15%. The advantage of preparing platinum catalyst with (trimethyl)methylcyclopentadienylplatinum(IV) as precursor was that no acid-catalysed products were then formed in the hydrogenation reaction. (C) 2004 Elsevier B.V. All rights reserved.
引用
收藏
页码:129 / 137
页数:9
相关论文
共 26 条
[1]   PREPARATION OF ALUMINA-SUPPORTED PLATINUM CATALYST AT AMBIENT-TEMPERATURE FOR SELECTIVE SYNTHESIS OF CINNAMYL ALCOHOL BY LIQUID-PHASE CINNAMALDEHYDE HYDROGENATION [J].
ARAI, M ;
USUI, K ;
NISHIYAMA, Y .
JOURNAL OF THE CHEMICAL SOCIETY-CHEMICAL COMMUNICATIONS, 1993, (24) :1853-1854
[2]   INTERACTION OF CO WITH PLATINUM SPECIES IN ZEOLITES - EVIDENCE FOR PLATINUM CARBONYLS IN PARTIALLY REDUCED ZEOLITE PTNAX [J].
BISCHOFF, H ;
JAEGER, NI ;
SCHULZEKLOFF, G ;
KUBELKOVA, L .
JOURNAL OF MOLECULAR CATALYSIS, 1993, 80 (01) :95-103
[3]   ALKANE CONVERSION AND TOPOLOGICAL SEGREGATION IN PTM/AL2O3 CATALYSTS [J].
COQ, B ;
CHAQROUNE, A ;
FIGUERAS, F ;
NCIRI, B .
APPLIED CATALYSIS A-GENERAL, 1992, 82 (02) :231-245
[4]   Structure-activity relationships in catalysis by metals: some aspects of particle size, bimetallic and supports effects [J].
Coq, B ;
Figueras, F .
COORDINATION CHEMISTRY REVIEWS, 1998, 178 :1753-1783
[5]   Structure sensitivity of the hydrogenation of crotonaldehyde over Pt/SiO2 and Pt/TiO2 [J].
Englisch, M ;
Jentys, A ;
Lercher, JA .
JOURNAL OF CATALYSIS, 1997, 166 (01) :25-35
[6]  
FRITSCH A, 1987, SURF SCI, V184, pL355, DOI 10.1016/S0039-6028(87)80262-5
[7]   Selective hydrogenation of α,β-unsaturated aldehydes [J].
Gallezot, P ;
Richard, D .
CATALYSIS REVIEWS-SCIENCE AND ENGINEERING, 1998, 40 (1-2) :81-126
[8]  
Gallezot P., 1991, CATALYSIS ORGANIC RE, P1
[9]   HYDROGENATION OF CINNAMALDEHYDE OVER RU/C CATALYSTS - EFFECT OF RU PARTICLE-SIZE [J].
GALVAGNO, S ;
CAPANNELLI, G ;
NERI, G ;
DONATO, A ;
PIETROPAOLO, R .
JOURNAL OF MOLECULAR CATALYSIS, 1991, 64 (02) :237-246
[10]   CHEMOSELECTIVITY IN THE CATALYTIC-HYDROGENATION OF CINNAMALDEHYDE - EFFECT OF METAL-PARTICLE MORPHOLOGY [J].
GIROIRFENDLER, A ;
RICHARD, D ;
GALLEZOT, P .
CATALYSIS LETTERS, 1990, 5 (02) :175-182