A COMPARISON OF THE INFLAMMATORY RESPONSE OF THE LUNG TO INHALED VERSUS INSTILLED PARTICLES IN F344 RATS

The potential pulmonary toxicity of poorly soluble airborne dusts generated in industrial and environmental settings is often evaluated by inhalation studies in rodents. Studies using intratracheal instillation of particles have been suggested as a less expensive alternative. We conducted a study to compare the inflammatory response of the lung to instilled versus inhaled particles. In one study, female F344/N rats, 11-13 weeks of age, were exposed for 6 hr/day, 5 days/week for 4 weeks by inhalation to 0, 0.1, 1.0, or 10 mg/m(3) of either alpha-quartz (toxic particle) or TiO2 (relatively low toxicity particle) and the lung burdens were determined at I week after the end of the exposure. The lungs were evaluated by analysis of bronchoalveolar lavage fluid (BALF) at 1, 8, and 24 weeks after the end of the exposure and by histopathology at 24 weeks. In a second study, rats were exposed by instillation to the lung burdens present in the preceding study at 1 week after the inhalation exposure, and the rats were evaluated in the same manner as in the inhalation study. In general, the degree of alveolitis, as evaluated by histopathology and BALF analysis, was similar by the two methods of exposure. With lung burdens up to 750 mu g/g lung, the TiO2 elicited no changes in BALF parameters at any time by either method of exposure, nor was any histopathology observed. The BALF changes elicited by alpha-quartz were of approximately the same magnitude and followed the same time course by either exposure method with the lowest dose delivered to the lung by either method being a ''no-effect'' dose. At the highest dose, microgranulomas were observed in bronchial-associated lymphoid tissue (BALT) in both sets of rats. However, the highest inhalation exposure induced pleural granulomatous lesions that were not observed in the animals instilled with alpha-quartz. The results indicate that the relative potentials of the two materials to produce bronchoalveolitis and granulomatous lesions in BALT could be appropriately evaluated using either intratracheal or inhalation exposures. (C) 1995 Society of Toxicology.