Partial oxidation of methane to synthesis gas via the direct reaction scheme over Ru/TiO2 catalyst

被引：101

作者：

Boucouvalas, Y

Zhang, ZL

Verykios, XE

机构：

[1] Department of Chemical Engineering, Inst. Chem. Eng. High Temp. P., University of Patras

来源：

CATALYSIS LETTERS | 1996年 / 40卷 / 3-4期

关键词：

methane; partial oxidation of; natural gas; utilization; synthesis gas; production of; ruthenium; catalyst; titanium dioxide; catalyst carrier;

D O I：

10.1007/BF00815281

中图分类号：

O64 [物理化学（理论化学）、化学物理学];

学科分类号：

070304 ; 081704 ;

摘要：

The partial oxidation of methane to synthesis gas has been investigated over various supported metal catalysts. The effects of operational variables on mass and heat transport resistances were investigated for defining the kinetic regime. It is observed that, in the absence of significant mass and heat transfer resistances, high selectivity (up to 65%) to synthesis gas is obtained over Ru/TiO2 catalysts in the low methane conversion range (X(O2) < 100%) whereas only negligibly small selectivity to synthesis gas is observed over all other catalysts investigated under similar conditions. This indicates that the Ru/TiO2 catalyst possesses unique properties, offering high selectivity to synthesis gas formation via the direct reaction scheme, whereas the other catalysts promote the sequence of total oxidation of methane to CO2 and H2O, followed by reforming reactions to synthesis gas. An increase of selectivity to synthesis gas, in the presence of oxygen, is achieved over the Ru/TiO2 catalyst by multi-feeding oxygen, which is attributed to suppression of deep oxidation of H-2 and CO.

引用

页码：189 / 195

页数：7

共 12 条

[1] SELECTIVE OXIDATION OF METHANE TO SYNTHESIS GAS-USING TRANSITION-METAL CATALYSTS [J].

ASHCROFT, AT ;

CHEETHAM, AK ;

FOORD, JS ;

GREEN, MLH ;

GREY, CP ;

MURRELL, AJ ;

VERNON, PDF .

NATURE, 1990, 344 (6264) :319-321

[2] HEAT-TRANSPORT LIMITATIONS AND REACTION SCHEME OF PARTIAL OXIDATION OF METHANE TO SYNTHESIS GAS OVER SUPPORTED RHODIUM CATALYSTS [J].

BOUCOUVALAS, Y ;

ZHANG, ZL ;

VERYKIOS, XE .

CATALYSIS LETTERS, 1994, 27 (1-2) :131-142

[3]

BOUCOUVALAS Y, 1996, 11 INT C CAT BALT

[4] ARE THE EQUILIBRIUM CONCENTRATIONS OF CO AND H-2 EXCEEDED DURING THE OXIDATION OF CH4 OVER A NI/YB2O3 CATALYST [J].

DISSANAYAKE, D ;

ROSYNEK, MP ;

LUNSFORD, JH .

JOURNAL OF PHYSICAL CHEMISTRY, 1993, 97 (15) :3644-3646

[5] PARTIAL OXIDATION OF METHANE TO CARBON-MONOXIDE AND HYDROGEN OVER A NI/AL2O3 CATALYST [J].

DISSANAYAKE, D ;

ROSYNEK, MP ;

KHARAS, KCC ;

LUNSFORD, JH .

JOURNAL OF CATALYSIS, 1991, 132 (01) :117-127

[6] SYNTHESIS GAS-FORMATION BY DIRECT OXIDATION OF METHANE OVER RH MONOLITHS [J].

HICKMAN, DA ;

HAUPFEAR, EA ;

SCHMIDT, LD .

CATALYSIS LETTERS, 1993, 17 (3-4) :223-237

[7] SYNTHESIS GAS-FORMATION BY DIRECT OXIDATION OF METHANE OVER PT MONOLITHS [J].

HICKMAN, DA ;

SCHMIDT, LD .

JOURNAL OF CATALYSIS, 1992, 138 (01) :267-282

[8]

Rostrup-Nielsen J.R., 1984, CATAL SCI TECHNOL, V5, P1, DOI [10.1007/978-3-642-93247-2_1, DOI 10.1007/978-3-642-93247-2_1, DOI 10.1007/978-3-642-93247-2_]

[9] COMPARISON OF MONOLITH-SUPPORTED METALS FOR THE DIRECT OXIDATION OF METHANE TO SYNGAS [J].

TORNIAINEN, PM ;

CHU, X ;

SCHMIDT, LD .

JOURNAL OF CATALYSIS, 1994, 146 (01) :1-10

[10]

VANHOOK JP, 1981, CATAL REV SCI ENG, V21, P1

← 1 2 →