Synthesis of highly conductive boron-doped p-type hydrogenated microcrystalline silicon (μc-Si:H)by a hot-wire chemical vapor deposition (HWCVD) technique

Boron-doped hydrogenated microcrystalline silicon (mu c-Si:K) films were prepared using hot-wire chemical vapor deposition (HWCVD) technique. Structural, electrical and optical properties of these thin films were systematically studied as a function of B2H6 gas (diborane) phase ratio (Variation in B2H6 gas phase ratio, dopant gas being diluted in hydrogen, affected the film properties through variation in doping level and hydrogen dilution). Characterization of these films from low angle X-ray diffraction and Raman spectroscopy revealed that the high conductive film consists of mixed phase of microcrystalline silicon embedded in an amorphous network. Even a small increase in hydrogen dilution showed marked effect on film microstructure. At the optimized deposition conditions, films with high dark conductivity (0.08 (Omega cm)(-1)) with low charge carrier activation energy (0.025 eV) and low optical absorption coefficient with high optical band gap (similar to 2.0 eV) were obtained. At these deposition conditions, however, the growth rate was small(6 Angstrom/s) and hydrogen content was large (9 at%). (C) 2000 Elsevier Science B.V. All rights reserved.