Morphine pharmacokinetics after pulmonary administration from a novel aerosol delivery system

Background: Successful pharmacotherapy of pain often depends on the mode of drug delivery. A novel, unit dose, aqueous aerosol delivery system (AERx Pulmonary Drug Delivery System) was used to examine the feasibility of the pulmonary route for the noninvasive systemic administration of morphine. Methods: The study had two parts: (1) a dose-ranging study in four subjects with three consecutive aerosolized doses of 2.2, 4.4, and 8.8 mg (nominal) morphine sulfate pentahydrate at 40-minute intervals, and (2) a crossover study, on separate days, in six subjects with 4.4 mg (nominal) aerosolized morphine sulfate administered over 2.1 minutes on three occasions and intravenous infusions of 2 and 4 mg over 3 minutes. Subjects were healthy volunteers from 19 to 34 years old. Arterial blood was sampled for a total of 6 hours and plasma morphine concentrations were measured by gas chromatography-mass spectrometry. Results: In part 1, plasma morphine concentrations were proportional to dose. In part 2, the mean I SD peak plasma concentration (C-max) occurred at 2.7 +/- 0.8 minutes after the aerosol dose, with mean values for C-max of 109 +/- 85, 165 +/- 22, and 273 +/- 114 ng/ml for the aerosol and 2 and 4 mg intravenous doses, respectively. The bioavailability [AUC(0-360 min)] of aerosol-delivered morphine was approximately 100% relative to intravenous infusion, with similar intersubject variability in AUC for both routes (coefficient of variation < 30%). Conclusion: The time courses of plasma morphine concentrations after pulmonary delivery by the AERx system and by intravenous infusions were similar. This shows the utility of the pulmonary route in providing a noninvasive method for the rapid and reproducible systemic administration of morphine if an appropriate aerosol drug delivery system is used.