COMPARISON OF HYDROLYSIS AND ESTERIFICATION BEHAVIOR OF HUMICOLA LANUGINOSA AND RHIZOMUCOR-MIEHEI LIPASES IN AOT-STABILIZED WATER-IN-OIL MICROEMULSIONS .1. EFFECT OF PH AND WATER-CONTENT ON REACTION-KINETICS

Lipolase and Lipozyme are produced in large quantities (as a result of genetic engineering and overexpression) for the detergents market and provide a cheap source of highly active biocatalysts. Humicola lanuginosa lipase (HIL) and Rhizomucor miehei lipase (RmL) have been isolated in partially purified form from commercial preparations of Lipolase and Lipozyme, respectively. These lipases were solubilized in Aerosol-OT (AOT)-stabilized water-in-oil (w/o) microemulsions in n-heptane. HIL and RmL activity in these microemulsions was assayed by spectrophotometric measurement of the initial rate of p-nitrophenyl butyrate hydrolysis, and by chromatographic determination of the initial rate of octyl decanoate synthesis from l-octanol and decanoic acid. The hydrolytic activity of RmL in microemulsions measured as a function of buffer pH prior to dispersal, followed a sigmoidal profile with the highest activities observed at alkaline pi-is. This broadly matches the pH-activity profile for tributyrin hydrolysis by Lipolase in an aqueous emulsion assay. The hydrolytic activity of RmL in the same microemulsions, measured as a function of pH, gave a bell-shaped profile with a maximum activity at pH 7.5. Again, the observed pH-activity profile was similar to that reported for a purified RmL in a tributyrin-based aqueous emulsion assay. In contrast, the esterification activity exhibited by both HIL and RmL in AOT microemulsions over the available range pH 6.1 to 10.4, decreases as the pH increases, most likely reflecting the effect of substrate ionization. The dependence of the hydrolytic and condensation activity of HIL on R, the mole ratio of water to surfactant, were similar with both profiles exhibiting a maximum at R = 5. The hydrolytic and esterification activities of RmL followed similar R-dependent profiles, but the profiles in this case exhibited a maximum at R = 10. The water activities at these R values were directly measured as 0.78 and 0.9, respectively. Measured water activities were unperturbed by the presence of lipase at the concentrations used in these studies. (C) 1995 John Wiley & Sons, Inc.